回轉式鼓風機安裝尺寸
Installation dimension of rotary blower
1、 體積小、風量大、噪聲低、耗能省(回轉式鼓風機采用運轉壓縮空氣的原理，雖然體積小，但風量大、，靜音運轉是其他形式的風機無法比擬的;
1. Small volume, large air volume, low noise and low energy consumption (the rotary blower adopts the principle of operating compressed air. Although the volume is small, it has large air volume, energy saving and silent operation, which is unmatched by other types of fans;
2、運轉平穩，安裝方便(小型機種運轉時只要放置妥當則振動很小，不需要加裝防振裝置，安裝方便);
2. Stable operation and convenient installation (small models have little vibration as long as they are properly placed during operation, so it is not necessary to install anti vibration devices, which is convenient for installation);
3、抗負荷變化，風量穩定(例如：污水處理曝氣槽壓力變化，則負荷變化，但風量隨壓力變化而變化甚微)。
3. Resistant to load change and stable air volume (for example, if the pressure of sewage treatment aeration tank changes, the load changes, but the air volume changes little with the pressure change).
4、附有空氣室，散氣平穩(全部機種附有空氣室，可防止空氣脈動，散氣平穩);
4. Air chamber is provided for stable air dispersion (air chamber is provided for all models to prevent air pulsation and smooth air dispersion);
5、材質精良，結構巧妙，性能好(鼓風機全部采用的材料，結構精巧，堅固耐用，性能好，長期使用故障少);
5. Excellent material, ingenious structure and good performance (all blowers are made of high-quality materials, with exquisite structure, durability, good performance and few long-term faults);
6、保養簡單，故障少，壽命長(低轉速，磨損小，壽命長)。
6. Simple maintenance, few faults and long service life (low speed, little wear and long service life).
回轉式鼓風機安裝效果
Installation effect of rotary blower
1、搬運回轉式鼓風機時請?zhí)貏e注意，要避免回轉式鼓風機受到碰傷和沖擊，且不能把回轉式鼓風機立起來搬運，以防止?jié)櫥蛷挠拖鋬?nèi)倒出來。
1. Please pay special attention to safety when handling the rotary blower. Avoid bumping and impact on the rotary blower, and do not lift the rotary blower to prevent the lubricating oil from pouring out of the oil tank.
2、風機房應留有通風口并安裝 換氣扇 ，通風口要設在上下兩處便于空氣對流，以防止機房?jī)?nèi)溫度過高影響回轉式鼓風機正常運行。
2. The fan room shall be provided with air vents and installed with ventilation fans. The vents shall be set at the upper and lower places to facilitate air convection, so as to prevent excessive temperature in the machine room from affecting the normal operation of the rotary blower.
3、機房?jī)?nèi)壁周圍裝有消音材料以降低噪音。
3. It is better to install silencing materials around the inner wall of the machine room to reduce noise.
4、回轉式鼓風機應水平安裝。
4. The rotary blower shall be installed horizontally.
5、配氣管徑不應小于回轉式鼓風機排風口徑，并注意管內清潔，送氣管應安裝在水面以上，以防止管內進水造成起動時壓力過大。
5. The air distribution pipe diameter shall not be less than the exhaust diameter of the rotary blower, and attention shall be paid to the cleanness in the pipe. The air supply pipe shall be installed above the water surface to prevent excessive pressure during startup caused by water inflow in the pipe.
6、接管時注意不要把止回閥擰倒(止回閥凸起部分應朝上)。
6. Be careful not to screw down the check valve (the convex part of the check valve should face upward) when connecting the pipe.
7、請正確接配電線并注意電機轉向與回轉式鼓風機旋轉方向標記一致。
7. Please connect the distribution wire correctly and note that the rotation direction of the motor is consistent with that of the rotary blower.
8、采用兩臺回轉式鼓風機交替運行時，應避免在短時間內頻繁交換起動風機，希望一臺回轉式鼓風機的連續運行時間不低于12小時。
8. When two rotary blowers are used for alternate operation, frequent exchange of starting fans in a short time shall be avoided. It is hoped that the continuous operation time of one rotary blower shall not be less than 12 hours.
以上就是舒適為大家介紹的回轉式鼓風機的一些簡單知識，在鼓風機的市場中，不同種類的鼓風機是有很多的，而回轉式鼓風機能在眾多的鼓風機中脫穎而出是因?yàn)樗鼉?yōu)良的質量以及良好的通風效果。回轉式鼓風機的安裝也是使用中一個非常重要的環節，只有安裝好了才能發揮出它好的效果。
The above is some simple knowledge of the rotary blower introduced to you by comfort. In the blower Market, there are many different types of blowers, and the rotary blower stands out among many blowers because of its excellent quality and good ventilation effect. The installation of the rotary blower is also a very important link in the use. Only when it is installed can it play a good role.
TEL:400-9901-557
TEL:18678880998
公司地址：山東省濟南市章丘區相公街道大康村村南
濟南道源豐達機械制造有限公司
備案號：魯ICP備2022009540號-1 魯公網安備37018102000745號
